Self-service car washes

Machinery

Machines and devices installed in Auto-Spa car wash network.

• HIGH PRESSURE PUMP CAT 3CP 1140 - efficiency 11 l/minute at 1420 rev/min, pressure 95-150 bar, water flow rate 660 l/h (from each stand), overflow valve, brass-made, stainless spring, Viton gasket, pressure at work up to 250 bar, smooth pressure regulation
• SIEMENS ELECTRIC ENGINE - power 2,2 kW, speed 1420 rev/min
• ANTI-PULSE BATTERY- suppresses pressure jumps which extends the durability of high pressure elements. The application of the battery diminishes pressure rush in a wash pipe simultaneously increasing use comfort
• VIP AIR-OPERATED CONTROL VALVES
• AIR DOSING PUMP - gaskets and a membrane resistant to wax and polish activity
• CONDENSATION BOILER Hoval TopGas 80 - power 80 kW, stainless steel combustion chamber, efficiency up to 108%, burner power modulation, hot water tank capacity – 149 litres, water temperature range – 30-70ºC, double-wall stainless steel chimney pipe of the length of 3 m
• CIRCULATING PUMPS - Grundfos
• HEAT EXCHANGERS in stainless steel plate housing
• POWDER FEED – worm, stainless steel made, power supply 3N 400 V / 50 Hz, 24,5 kW

• REVERSED OSMOSIS SYSTEM - in the event of a failure, the system automatically starts to absorb water from the network, water conductivity control is assured, pressure control protective system in the event of the lack of water, efficiency 650 l/h (at temperature of 10oC), water filter osmosis inlet with the accuracy of 5μm,
• CYCLIC RINSING SYSTEM OF MEMBRANES
• FLOW RATE CONTROL WITH ROTAMETERS
• OSMOSIS TANK - capacity of 800 litres, rate control by means of 3 float valves
• IMPELLER PUMP - staged, power 1,1kW, rev speed 2900 rev/min, efficiency up to 120 m3/h, pressure up to 30 bar, engine power modulation by means of inverter depending on load, stainless-made
• TWO-COLUMN SOFTENING SYSTEM - 2 x 105 litres, softeners capacity 2x150m3/24 hours, fully automatic control over watering softening system with a processor.
• SALT TANK 190 litres
• PARAMETER CONTROL PANEL

• COMPUTER WITH A CONTROL PANEL- total control over all car wash parameters, possibility to change powder feed setpoints, operating time etc., income control on separate stands with segregation of individual coins, amount of powder used, possibility to disconnect individual valves and car wash sections (excluding offline furnace and water softening system)
• HYDRONET REMOTE ACCESS SYSTEM - remote carwash preview (identical function to physical presence in front of a control panel), via GSM, broadband internet connection, if it is available (up to 100m) close to a carwash
• CONTROL DEVICES (panel + controller) – system based on Swiss MicroInnovation supported by Moeller Electric group.
• INVERTERS - due to innovative automatics system applied consisting in using inverters, we have a possibility to control engine revolves, thus we are enabled to use lower pressure rates on individual programs preserving the highest quality of washing. It provides us with an opportunity to cut expenditures on both water and electricity supplies and on chemical agents which undoubtedly influences environment protection. The savings reach 30%.
• WEATHER SENSORS - they adjust the work of a furnace, depending on the outside temperature, power devoted to heating up the floor is lower in proportion to increases of the temperature outside.
• TWILIGHT SENSORS AND LIGHT CONTROL SYSTEM- advertising lighting turns on after sunset, main lighting of stands turns on after selecting washing program and goes out after two minutes after use.